Ni80Fe20镀层对Fe73.5Cu1Nb3Si13.5B9非晶条带的巨磁阻抗效应的影响

doi:10.3969/j.issn.1000-5641.2017.01.009

摘要/Abstract

摘要：

采用磁控溅射镀膜工艺, 在Fe_73.5Cu₁Nb₃Si_13.5B₉非晶条带的光滑面上溅射了 130~650 nm厚的Ni₈₀Fe₂₀薄膜, 制备了一系列 Ni₈₀Fe₂₀ / Fe_73.5Cu₁Nb₃Si_13.5B₉复合结构样品. 研究了镀层厚度对材料的镀层形貌、巨磁阻抗效应(Giant Magneto-Impedance, GMI)和磁滞回线的影响. 结果发现, 镀层厚度为 260nm 厚时, 样品的表面形貌最平整致密, 最大磁阻抗比提高到 33.0%. 在玻璃基片上溅射了相同厚度的系列Ni₈₀Fe₂₀薄膜, 其磁滞回线结果发现薄膜的各向异性方向随着厚度的增加由平行表面转变成垂直于表面. 正是Ni₈₀Fe₂₀镀层各向异性的方向改变, 影响了镀层与条带间的相互作用, 进而影响复合结构样品的磁阻抗效应.

关键词: 相互作用, 磁阻抗效应, 复合结构

Abstract:

Different thickness of Ni₈₀Fe₂₀ films are deposited on the Fe_73.5Cu₁Nb₃Si_13.5B₉ amorphous ribbons using RF (radio frequency) magnetron sputtering method. The magnetic properties and magneto impedance effect are measured and compared with as-cast Fe_73.5Cu₁Nb₃Si_13.5B₉amorphous ribbons. The results show that the ribbon coated with 260 nm Ni₈₀Fe₂₀ layer achieves a much better performance than others, which produces a GMI (giant magneto-impedance) ratio of 33.0%. It is found that the surface of 260 nm Ni80Fe20 layer is smoother and the particle size is relatively smaller. The hysteresis loops of the ribbons with and without Ni₈₀Fe₂₀ coating layer are almost unchanged. However, the hysteresis loops of the Ni₈₀Fe₂₀ films sputtered onto glass substrate indicate the shift of anisotropy direction from parallel to normal to the surface as the thickness increases. The shifting will influence the magnetic exchange interaction between the amorphous ribbons and the Ni₈₀Fe₂₀ coating layers. The variation of GMI effect can be interpreted by the surface structure and magnetic exchange interaction.

Key words: exchange interaction, magneto-impedance, composite structure

韩洋; 吕文星; 赵振杰; . Ni₈₀Fe₂₀镀层对Fe_73.5Cu₁Nb₃Si_13.5B₉非晶条带的巨磁阻抗效应的影响[J]. 华东师范大学学报(自然科学版), doi: 10.3969/j.issn.1000-5641.2017.01.009.

HAN Yang, LYU Wen-xing, ZHAO Zhen-jie. Magneto-impedance effect of amorphous Fe_73.5Cu₁Nb₃Si_13.5B₉ ribbons with Ni₈₀Fe₂₀ permalloy film[J]. Journal of East China Normal University(Natural Sc, doi: 10.3969/j.issn.1000-5641.2017.01.009.

参考文献

[ 1 ] MOHRI K, KOHSAWA T, KAWASHIMA K, et al. Magneto-inductive effect (MI effect) in amorphous wires [J].IEEE Transactions on Magnetics, 1992, 28(5): 3150-3152.
[ 2 ] CHEN D L, ZHAO Z J, JIANG L, et al. Effect of rotating direction and interval on giant magneto-impedance of sputtered Ni80Fe20/Cu composite wires [J]. Surface Review and Letters, 2011, 18(06): 223-227.
[ 3 ] CHIRIAC H, CORODEANU S, DONAC A, et al. Influence of cold drawing on the magnetic properties and giant magneto-impedance response of FINEMET nanocrystalline wires [J]. Journal of Applied Physics, 2015, 117(17):17A-314A.
[ 4 ] WU Z M, ZHAO Z J, LIU L P, et al. Enhancement of giant magento-impedance effect using LC resonance [J].Surface Review and Letters, 2008, 15(01n02): 87-90.
[ 5 ] ZHUKOV A, IPATOV M, CHURYUKANOVA M, et al. Giant magneto-impedance in thin amorphous wires: From manipulation of magnetic field dependence to industrial applications [J]. Journal of Alloys and Compounds,2014, 586: S279-S286.
[ 6 ] GARC´IA-CHOCANO V M, GARC´IA-MIQUEl H. DC and AC linear magnetic field sensor based on glass coated amorphous microwires with giant magneto-impedance [J]. Journal of Magnetism and Magnetic Materials, 2015, 378: 485-492.
[ 7 ] ZHANG Q, MAO Q M, RUAN J Z, et al. Giant magneto-impedance effect of magnetron sputtered Ni80Fe20/Cu composite wires [J]. Surface Review and Letters, 2008, 15(6): 753-756.
[ 8 ] CO¨ISSON M, TIBERTO P, VINAI F, et al. Penetration depth and magnetic permeability calculations on GMI effect and comparison with measurements on CoFeB alloys [J]. Journal of Magnetism and Magnetic Materials, 2008, 320(3): 510-514.
[ 9 ] GUO H Q, KRONM¨ ULLER H, DRAGON T, et al. Influence of nanocrystallization on the evolution of domain patterns and the magneto-impedance effect in amorphous Fe73.5Cu1Nb3Si13.5B9 ribbons [J]. Journal of Applied Physics, 2001, 89(1): 514-520.
[10] TINH N H, DUNG N V, NGHI N H, et al. Influence of Nb substitution for Fe on the magnetic and magnetoimpedance properties of amorphous and annealed Fe76.5-xSi13.5B9Cu1Nbx(x=0-7) ribbons [J]. Physica B: Condensed Matter, 2012, 407(18): 3790-3796.
[11] GONA M N, YANASE S, HASHI S, et al. Magneto-impedance effect in nanocrystalline FeZrNbB ribbons [J]. Journal of magnetism and magnetic materials, 2003, 254: 466-468.
[12] YOON S S, KIM C G, JANG K J, et al. Effect of annealing field orientation on GMI profiles in Co-based amorphous ribbon [J]. IEEE Transactions on Magnetics, 2000, 36(5): 2872-2874.
[13] BRUNETTI L, TIBERTO P, VINAI F, et al. High-frequency giant magneto impedance in joule-heated Co-based amorphous ribbons and wires [J]. Materials Science and Engineering: A, 2001, 304: 961-964.
[14] KAVIRAJ B, GHATAK S K. Influence of microwave annealing on GMI response and magnetization of an amorphous Fe73.5Nb3Cu1Si13.5B9 ribbon [J]. Solid State Communications, 2006, 140(6): 294-298.
[15] PANINA L V, MOHRI K. Magneto-impedance effect in amorphous wires [J]. Applied Physics Letters, 1994, 65(9): 1189-1191.
[16] LI B, SALEM N P M H, GIOUROUDI I, et al. Integration of thin film giant magneto-impedance sensor and surface acoustic wave transponder [J]. Journal of Applied Physics, 2012, 111(7): 7E-514E.
[17] CHEN L, ZHOU Y, LEI C, et al. Effect of sputtering parameters and sample size on giant magneto-impedance effect in NiFe and NiFe/Cu/NiFe films [J]. Materials Science and Engineering: B, 2010, 172(2): 101-107.
[18] JIANG L, TAN L S, RUAN J Z, et al. Intermittent deposition and interface formation on the microstructure and magnetic properties of NiFe/Cu composite wires [J]. Physica B: Condensed Matter, 2008, 403(18): 3054-3058.
[19] NING N, FAN J, WU J, et al. NiFe/insulator/Cu composite wires and their giant magneto-impedance effects [J]. Surface Review and Letters, 2010, 17(03): 369-373.
[20] CHEN D L, LI X, PAN H L, et al. Magneto-impedance effect of composite wires prepared by chemical plating under DC current [J]. Nano-Micro Letters, 2014, 6(3): 227-232.
[21] LAURITA N, CHATURVEDI A, BAUER C, et al. Enhanced giant magneto-impedance effect and field sensitivity in Co-coated soft ferromagnetic amorphous ribbons [J]. Journal of Applied Physics, 2011, 109(7): 7C-706C.
[22] CHEN D, LI X, JI X, et al. Magneto-impedance effect of the Ni80Fe20/Cu composite wires: The influence of DC current imposed on the Cu base [J]. AIP Advances, 2014, 4(6): 67133.
[23] LIU Y, SELLMYER D J, SHINDO D. Handbook of Advanced Magnetic Materials [M]. Berlin: Springer Science & Business Media, 2008.
[24] LI X P, SEET H L, FAN J, et al. Electrodeposition and characteristics of Ni80Fe20/Cu composite wires [J]. Journal of Magnetism and Magnetic Materials, 2006, 304(1): 111-116.

[1]	秦宇昕, 柳银萍, 徐桂琼. 两个含时变系数的高维非线性演化方程新型孤子和多波解[J]. 华东师范大学学报（自然科学版）, 2023, 2023(4): 1-10.
[2]	苏亚攀, 潘海林, 赵振杰, 袁萌平. 磁偶极作用对铁基纳米晶条带LDGMI效应的影响[J]. 华东师范大学学报(自然科学版), 2018, 2018(3): 129-135,156.
[3]	张恒广, 李欣, 阮建中, 陈德禄, 赵振杰. 真空退火对Co_81.5Fe_4.5Mo₂B₁₂玻璃包裹丝巨磁阻抗效应的影响[J]. 华东师范大学学报(自然科学版), 2014, 2014(6): 67-72.
[4]	栾红艳, 李欣, 王蕊丽, 潘海林, 陈德禄, 赵振杰. pH值对电流化学镀复合结构丝的性能影响研究[J]. 华东师范大学学报(自然科学版), 2013, 2013(6): 127-132.
[5]	王蕊丽，阮建中，孔祥洪，杨渭，王江涛，赵振杰. 外镀铜层玻璃包裹丝的巨磁阻抗效应[J]. 华东师范大学学报(自然科学版), 2013, 2013(1): 115-120.
[6]	于群;;周发琇;王启. 海洋影响下的山东半岛冷流降雪[J]. 华东师范大学学报(自然科学版), 2009, 2009(3): 160-169.
[7]	蒋玲;阮建中;赵强;王清江;赵振杰. 溅射工艺对NiFe/Cu复合丝结构和性能的影响[J]. 华东师范大学学报(自然科学版), 2008, 2008(5): 104-109.
[8]	袁立;杨燮龙;赵振杰. 电流退火对钴基非晶丝巨磁阻抗效应的影响[J]. 华东师范大学学报(自然科学版), 2008, 2008(3): 120-124.
[9]	吴志明;赵振杰;刘龙平;杨燮龙. LC共振增强巨磁阻抗效应[J]. 华东师范大学学报(自然科学版), 2007, 2007(5): 123-127.
[10]	边成香;徐学诚;杨国光 . 导电复合材料磺化聚苯乙炔/多壁碳纳米管研究 [J]. 华东师范大学学报(自然科学版), 2007, 2007(3): 127-134.
[11]	宋子成;袁望治;赵振杰;阮建中;杨燮龙 . Ni₈₀Fe₂₀复合结构多层膜的巨磁阻抗效应研究[J]. 华东师范大学学报(自然科学版), 2007, 2007(1): 127-134.
[12]	张军车;刘龙平;赵振杰;杨燮龙;王清江 . 铁基纳米晶玻璃包裹丝的直径对巨磁阻抗效应的影响[J]. 华东师范大学学报(自然科学版), 2007, 2007(1): 107-112.
[13]	吴士蓉;袁望治;阮建中;赵振杰;杨燮龙. 电流退火对NiFeP复合丝巨磁阻抗效应的影响[J]. 华东师范大学学报(自然科学版), 2006, 2006(3): 114-119.
[14]	杨燮龙;赵振杰;袁望治;刘龙平;吴志明. 纳米晶软磁材料的磁性与巨磁阻抗效应(特约综述)[J]. 华东师范大学学报(自然科学版), 2005, 2005(5/6): 25-39.
[15]	王蕊丽;赵振杰;袁望治;阮建中;刘龙平;杨燮龙. 复合玻璃包裹纳米晶细丝的巨磁阻抗效应[J]. 华东师范大学学报(自然科学版), 2005, 2005(5/6): 152-156.

Ni₈₀Fe₂₀镀层对Fe_73.5Cu₁Nb₃Si_13.5B₉非晶条带的巨磁阻抗效应的影响

Magneto-impedance effect of amorphous Fe_73.5Cu₁Nb₃Si_13.5B₉ ribbons with Ni₈₀Fe₂₀ permalloy film

RichHTML

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价